93196321 - tecshift.eu https://tecshift.eu/product-tag/93196321 Wed, 09 Sep 2026 10:55:28 +0000 en-US hourly 1 https://wordpress.org/?v=7.1.3 https://tecshift.eu/wp-content/uploads/2016/08/cropped-0-02-01-3e269b116e5ea5e93f4e9edd289890eef432293431498adfb1ac0c260eeb91be_full-32x32.jpg 93196321 - tecshift.eu https://tecshift.eu/product-tag/93196321 32 32 Elf Speedmatic robot oil https://tecshift.eu/product/automatic-gearbox-oil-1l Thu, 13 Feb 2025 14:40:24 +0000 https://tecshift.eu/?post_type=product&p=11922 ELF Speedmatic robotised gearbox oil 1L, OEM 7711228107. Suitable for Renault Trafic, Master, Opel Vivaro and gearbox actuator 309105236R 309101331R, 309100043R, 309105236R, 8200104609, 8200469700, 8200617985, 8200831969, 8200912223, 8200983194, 3057000Q1M, 3057000Q1L, 93161415, 93161981, 93198060, 93198492, 93196321, 93198611, 95509138, 95525926, 95529459, 4430566, 4432379, 4433286, 4435208, 4418791, 4449344, 4408093

The post Elf Speedmatic robot oil appeared first on tecshift.eu.

]]> Renault PA0 Quickshift / Tecshift Diagnostic Fault Codes

The table below contains Renault PA0 robotised gearbox diagnostic fault codes and short recommended checks.
It applies to Renault Trafic II Phase 2 and Renault Master II Phase 3 systems with Vdiag 05 or 09.

Important: This is a diagnostic reference. A fault code does not automatically mean that the complete gearbox actuator must be replaced.

Fault Code Description What to Check / Do
DF002 Transmission control unit fault Check gearbox ECU fuses, the 52-pin connector, permanent and ignition power supplies, grounds and wiring. If the fault remains, test or replace the control unit.
DF005 Hydraulic pressure sensor circuit Check the 30 A pump fuse, hydraulic-fluid level, pressure-sensor connector and wiring. Test pump operation. Replace the pressure sensor or pump unit if required.
DF039 Engine speed information fault Diagnose the engine-injection system. Check the gearbox ECU, injection ECU connectors and engine-speed signal wiring.
DF046 Multiplexed idle-speed request fault Test the CAN/multiplex network and diagnose the engine-injection system.
DF048 Vehicle speed information fault Check gearbox input speed, engine-speed information, clutch condition, speedometer operation, ABS connection and wiring. Perform a road test.
DF057 Gearbox input-speed sensor circuit Check sensor installation, connector and wiring. Verify vehicle-speed and engine-speed signals. Check clutch condition. Replace the sensor if necessary.
DF062 CAN communication fault Perform a complete CAN/multiplex network test. Check wiring, connectors, ECU power supplies and communication between control units.
DF065 Hydraulic pump relay circuit Diagnose DF005 first if present. Check the pump relay, relay socket, power supply, wiring, hydraulic pressure and pump motor.
DF066 Starter relay circuit Check the starter relay, relay socket, power supply, gearbox ECU connector and wiring. Test the relay with Renault CLIP command AC013.
DF067 Gear lever position switch circuit Check the gear-lever switch, connector and wiring. Verify lever-switch states ET043, ET044, ET045 and ET046 with Renault CLIP.
DF068 Clutch position sensor circuit Check sensor mounting, connector, wiring and the potentiometer mechanism. Inspect the clutch hydraulic circuit for leaks. Replace the sensor if necessary.
DF069 Selection position sensor circuit Check the sensor connector and wiring. Inspect the mechanical connection between the selection cylinder and potentiometer for wear, looseness or seizure.
DF070 Engagement position sensor circuit Check the sensor connector and wiring. Inspect the engagement cylinder-to-potentiometer linkage for excessive play, damage or seizure.
DF071 Clutch solenoid valve circuit Check the clutch-solenoid connector, ground and control wiring. Replace the clutch solenoid valve if the electrical circuit is correct.
DF072 Engagement solenoid valve 1 circuit Check the solenoid connector, ground and control wiring. Replace engagement solenoid valve 1 if necessary.
DF073 Engagement solenoid valve 2 circuit Check the solenoid connector, ground and control wiring. Replace engagement solenoid valve 2 if necessary.
DF074 Selection solenoid valve 1 circuit Check the solenoid connector, ground and control wiring. Replace selection solenoid valve 1 if necessary.
DF075 Selection solenoid valve 2 circuit Check the solenoid connector, ground and control wiring. Replace selection solenoid valve 2 if necessary.
DF076 Clutch control fault Check for clutch overheating, glazing and slipping. Inspect fluid level, hydraulic leaks, clutch actuator operation and the clutch solenoid valve.
DF077 Gearbox control fault Repair clutch and position-sensor faults first. Check the selection linkage, hydraulic pressure, solenoids, pressure accumulator, clutch cylinder and actuator. Perform gearbox learning after repair.
DF078 Hydraulic control fault Check that the pump starts at approximately 40 bar and stops at approximately 50 bar. Check fluid level, hydraulic leaks, pump condition and pressure accumulator.
DF080 Battery voltage fault Check the gearbox fuse, battery voltage, alternator output, battery terminals, engine grounds and ECU connectors.
DF082 Brake switch and stop-lamp circuit Check the stop-lamp fuse, brake-switch connector, switch installation and adjustment. Test the switch with the pedal pressed and released.
DF107 Multiplexed engine-speed information fault Repair DF062 first if present. Diagnose the injection system and engine-speed signal.
DF108 Multiplexed actual engine-torque information fault Repair DF062 first if present. Diagnose the injection system and engine-torque data.
DF144 Multiplexed coolant-temperature information fault Repair DF062 first if present. Diagnose the injection system and coolant-temperature sensor circuit.
DF145 Multiplexed accelerator-pedal position fault Repair DF062 first if present. Diagnose the injection system and both accelerator-pedal sensor tracks.
DF146 Multiplexed engine-torque information fault Repair DF062 first if present. Diagnose the injection system and engine-torque data.
DF148 Multiplexed secondary brake-switch information fault Repair DF062 first if present. Check the stop-lamp fuse, brake switch, adjustment, connector and wiring.
DF152 Multiplexed total mileage information fault Perform a complete CAN/multiplex network test.
DF153 Reverse-lamp command circuit Check the reverse-lamp relay, relay socket, power supply, gearbox ECU connector and wiring. Test with Renault CLIP command AC094.
DF183 UCH body-control-module message absent Perform a CAN/multiplex network test and check communication with the UCH body control module.
DF184 Instrument-cluster message absent Perform a CAN/multiplex network test and check communication with the instrument cluster.
DF186 Injection ECU message absent Repair DF062 first if present. Test the CAN network and communication with the injection ECU.
DF188 Robotised gearbox system operation fault Diagnose and repair all other present faults first. Clear the fault and road-test the vehicle.
DF189 Gear-position learning fault Run Renault CLIP command VP008. Confirm ET061 shows learning completed, then engage and verify every gear. Check actuators or internal gearbox mechanics if learning fails.
DF190 Clutch-position learning fault Run Renault CLIP command VP017. Cycle the ignition and confirm ET064 shows learning completed.

Source: Renault workshop manual MR-410-X83-21B000, PA0 robotised gearbox, Vdiag 05 and 09.

The post Elf Speedmatic robot oil appeared first on tecshift.eu.

]]> GEARBOX CONTROL Tiptronic Robot Actuator PA0 PK0 309105236R Vivaro Trafic https://tecshift.eu/product/gearbox-control-tiptronic-robot-actuator-pa0-pk0-309105236r-vivaro-trafic-2 https://tecshift.eu/product/gearbox-control-tiptronic-robot-actuator-pa0-pk0-309105236r-vivaro-trafic-2#respond Tue, 23 Aug 2016 12:08:26 +0000 https://tecshift.eu/product/gearbox-control-tiptronic-robot-actuator-pa0-pk0-309105236r-vivaro-trafic-2 Professionally reconditioned original gearbox actuator for selected
Renault Trafic and Master,
Opel/Vauxhall Vivaro and Movano, and
Nissan Primastar and Interstar vehicles fitted with compatible
PA0 or PK0 semi-automatic gearboxes.

  • OEM reference: 309105236R
  • Professionally reconditioned and tested
  • Controls clutch, gear selection and engagement
  • Supplied with a 1-year warranty
  • Worldwide delivery available

Please compare the OEM number on your original unit before ordering.
Contact us with your VIN or gearbox code if you need compatibility confirmation.

 

🔄 This is an exchange sale only — you need to return your old robot.

To proceed with the shipment of the robot unit, a €165 deposit is required:

• €130 — refundable deposit
• €35 — collection from your address. We will provide the return label. If collection is not available, we will provide you with our return address and you will need to arrange the return shipment yourself. In that case, the €35 collection fee will also be refunded together with the deposit.

💳 You can make the deposit payment here:
https://tecshift.eu/product/exchange-deposit-trafic-vivaro-gearbox-control

Once the deposit has been received, we will dispatch the robot unit.

The deposit will be refunded after we receive your old robot unit.

Alternatively, if you prefer not to pay the deposit, you may send your old robot unit to us first. Please let us know, and we will provide the return address.

⚠️ Please note that if the old robot unit is not returned, we will be unable to inspect it for damage or faults. In such cases, we cannot provide any warranty coverage for the robot unit you purchased.

The post GEARBOX CONTROL Tiptronic Robot Actuator PA0 PK0 309105236R Vivaro Trafic appeared first on tecshift.eu.

]]> 309105236R Reconditioned Gearbox Actuator

This professionally reconditioned 309105236R gearbox actuator
is suitable for selected Renault, Opel, Vauxhall and Nissan commercial vehicles
fitted with compatible PA0 or PK0 semi-automatic transmissions.

The unit may also be described as a gearbox robot, Quickshift actuator,
transmission actuator or automated manual gearbox control unit.

Each actuator is professionally inspected and tested for clutch operation,
gear selection and gear engagement before dispatch.

Product Features

  • Original OEM gearbox actuator
  • Professionally reconditioned
  • Fully inspected and function-tested
  • Suitable for compatible PA0 and PK0 gearboxes
  • Supplied with a 1-year warranty
  • Secure worldwide shipping

Compatible Vehicles

  • Renault Trafic II
  • Renault Master II
  • Opel Vivaro A
  • Vauxhall Vivaro A
  • Opel Movano A
  • Vauxhall Movano A
  • Nissan Primastar
  • Nissan Interstar

Important: Vehicle compatibility may vary depending on the
installed gearbox, vehicle specification and original actuator part number.
Always compare the OEM number on your original unit before ordering.

Compatible OEM Part Numbers

This gearbox actuator may replace or correspond with the following OEM references:

  • 3057000Q1L
  • 3057000Q1M
  • 309100042R
  • 309100043R
  • 309101331R
  • 309105236R
  • 4408093
  • 4449344
  • 7711228107
  • 8200104609
  • 8200469700
  • 8200617985
  • 8200831969
  • 8200912223
  • 8200983194
  • 93161981
  • 93196321
  • 93198060
  • 93198492
  • 93198611
  • 95509138
  • 95525926
  • 95529459

Common Related Fault Codes

Gearbox actuator or hydraulic-system problems may be associated with fault codes
including:


DF005, DF065, DF068, DF069, DF070, DF071, DF072, DF073, DF074,
DF075, DF076, DF077, DF078, DF188, DF189 and DF190.

A diagnostic fault code does not automatically confirm that the complete actuator
requires replacement. The hydraulic pressure, wiring, clutch, sensors, gearbox
control unit and mechanical gearbox condition should be diagnosed before ordering.

  • Sale
    ELF Speedmatic 1L hydraulic oil for Quickshift and Tecshift robotised gearboxes, OEM 7711228107
    Quick View
    Adding to cart
    −17%

    Elf Speedmatic robot oil
    , ,
    Original price was: €30.00.Current price is: €25.00.

Recommended Gearbox Robot Oil

For installation and servicing of this PA0 or PK0 gearbox actuator,
we recommend using only
ELF Speedmatic Robotised Gearbox Oil.

This oil is suitable for compatible Renault Trafic, Renault Master,
Opel/Vauxhall Vivaro, Opel/Vauxhall Movano, Nissan Primastar
and Nissan Interstar robotised gearbox systems.


Using the correct oil helps maintain proper hydraulic pressure,
smooth gear selection and correct gearbox actuator operation.


View ELF Speedmatic Robotised Gearbox Oil

Before Ordering

Please compare the part number on your original gearbox actuator with the numbers
listed above. If you are unsure about compatibility, send us the following details:

  • Vehicle VIN
  • Gearbox code
  • Original actuator OEM number
  • A clear photograph of the actuator label

We will help confirm compatibility before purchas

Exchange Terms and Surcharge

We sell this product on an exchange basis. Therefore, returning your old robot unit is required.

First, a core deposit of €165 is required before shipping. Alternatively, you can send your old unit first to avoid paying the surcharge deposit.

Warranty

This professionally reconditioned gearbox actuator is supplied with a
1-year warranty. Warranty conditions apply.

The post GEARBOX CONTROL Tiptronic Robot Actuator PA0 PK0 309105236R Vivaro Trafic appeared first on tecshift.eu.

]]> https://tecshift.eu/product/gearbox-control-tiptronic-robot-actuator-pa0-pk0-309105236r-vivaro-trafic-2/feed 0