Nissan Primastar / Interstar - tecshift.eu

Extra payment for a 1-year warranty

admin — Tue, 22 Sep 2026 11:01:27 +0000

Extra payment for a 1-year warranty

The post Extra payment for a 1-year warranty appeared first on tecshift.eu.

Renault Master 2.3 Diesel Engine Control Unit Ecu 310320197R

admin — Thu, 11 Dec 2025 11:32:35 +0000

Renault Master 2.3 Diesel Engine Control Unit Ecu 310320197R

The post Renault Master 2.3 Diesel Engine Control Unit Ecu 310320197R appeared first on tecshift.eu.

Elf Speedmatic robot oil

admin — Thu, 13 Feb 2025 14:40:24 +0000

Renault PA0 Quickshift / Tecshift Diagnostic Fault Codes

The table below contains Renault PA0 robotised gearbox diagnostic fault codes and short recommended checks.
It applies to Renault Trafic II Phase 2 and Renault Master II Phase 3 systems with Vdiag 05 or 09.

Important: This is a diagnostic reference. A fault code does not automatically mean that the complete gearbox actuator must be replaced.

Fault Code	Description	What to Check / Do
DF002	Transmission control unit fault	Check gearbox ECU fuses, the 52-pin connector, permanent and ignition power supplies, grounds and wiring. If the fault remains, test or replace the control unit.
DF005	Hydraulic pressure sensor circuit	Check the 30 A pump fuse, hydraulic-fluid level, pressure-sensor connector and wiring. Test pump operation. Replace the pressure sensor or pump unit if required.
DF039	Engine speed information fault	Diagnose the engine-injection system. Check the gearbox ECU, injection ECU connectors and engine-speed signal wiring.
DF046	Multiplexed idle-speed request fault	Test the CAN/multiplex network and diagnose the engine-injection system.
DF048	Vehicle speed information fault	Check gearbox input speed, engine-speed information, clutch condition, speedometer operation, ABS connection and wiring. Perform a road test.
DF057	Gearbox input-speed sensor circuit	Check sensor installation, connector and wiring. Verify vehicle-speed and engine-speed signals. Check clutch condition. Replace the sensor if necessary.
DF062	CAN communication fault	Perform a complete CAN/multiplex network test. Check wiring, connectors, ECU power supplies and communication between control units.
DF065	Hydraulic pump relay circuit	Diagnose DF005 first if present. Check the pump relay, relay socket, power supply, wiring, hydraulic pressure and pump motor.
DF066	Starter relay circuit	Check the starter relay, relay socket, power supply, gearbox ECU connector and wiring. Test the relay with Renault CLIP command AC013.
DF067	Gear lever position switch circuit	Check the gear-lever switch, connector and wiring. Verify lever-switch states ET043, ET044, ET045 and ET046 with Renault CLIP.
DF068	Clutch position sensor circuit	Check sensor mounting, connector, wiring and the potentiometer mechanism. Inspect the clutch hydraulic circuit for leaks. Replace the sensor if necessary.
DF069	Selection position sensor circuit	Check the sensor connector and wiring. Inspect the mechanical connection between the selection cylinder and potentiometer for wear, looseness or seizure.
DF070	Engagement position sensor circuit	Check the sensor connector and wiring. Inspect the engagement cylinder-to-potentiometer linkage for excessive play, damage or seizure.
DF071	Clutch solenoid valve circuit	Check the clutch-solenoid connector, ground and control wiring. Replace the clutch solenoid valve if the electrical circuit is correct.
DF072	Engagement solenoid valve 1 circuit	Check the solenoid connector, ground and control wiring. Replace engagement solenoid valve 1 if necessary.
DF073	Engagement solenoid valve 2 circuit	Check the solenoid connector, ground and control wiring. Replace engagement solenoid valve 2 if necessary.
DF074	Selection solenoid valve 1 circuit	Check the solenoid connector, ground and control wiring. Replace selection solenoid valve 1 if necessary.
DF075	Selection solenoid valve 2 circuit	Check the solenoid connector, ground and control wiring. Replace selection solenoid valve 2 if necessary.
DF076	Clutch control fault	Check for clutch overheating, glazing and slipping. Inspect fluid level, hydraulic leaks, clutch actuator operation and the clutch solenoid valve.
DF077	Gearbox control fault	Repair clutch and position-sensor faults first. Check the selection linkage, hydraulic pressure, solenoids, pressure accumulator, clutch cylinder and actuator. Perform gearbox learning after repair.
DF078	Hydraulic control fault	Check that the pump starts at approximately 40 bar and stops at approximately 50 bar. Check fluid level, hydraulic leaks, pump condition and pressure accumulator.
DF080	Battery voltage fault	Check the gearbox fuse, battery voltage, alternator output, battery terminals, engine grounds and ECU connectors.
DF082	Brake switch and stop-lamp circuit	Check the stop-lamp fuse, brake-switch connector, switch installation and adjustment. Test the switch with the pedal pressed and released.
DF107	Multiplexed engine-speed information fault	Repair DF062 first if present. Diagnose the injection system and engine-speed signal.
DF108	Multiplexed actual engine-torque information fault	Repair DF062 first if present. Diagnose the injection system and engine-torque data.
DF144	Multiplexed coolant-temperature information fault	Repair DF062 first if present. Diagnose the injection system and coolant-temperature sensor circuit.
DF145	Multiplexed accelerator-pedal position fault	Repair DF062 first if present. Diagnose the injection system and both accelerator-pedal sensor tracks.
DF146	Multiplexed engine-torque information fault	Repair DF062 first if present. Diagnose the injection system and engine-torque data.
DF148	Multiplexed secondary brake-switch information fault	Repair DF062 first if present. Check the stop-lamp fuse, brake switch, adjustment, connector and wiring.
DF152	Multiplexed total mileage information fault	Perform a complete CAN/multiplex network test.
DF153	Reverse-lamp command circuit	Check the reverse-lamp relay, relay socket, power supply, gearbox ECU connector and wiring. Test with Renault CLIP command AC094.
DF183	UCH body-control-module message absent	Perform a CAN/multiplex network test and check communication with the UCH body control module.
DF184	Instrument-cluster message absent	Perform a CAN/multiplex network test and check communication with the instrument cluster.
DF186	Injection ECU message absent	Repair DF062 first if present. Test the CAN network and communication with the injection ECU.
DF188	Robotised gearbox system operation fault	Diagnose and repair all other present faults first. Clear the fault and road-test the vehicle.
DF189	Gear-position learning fault	Run Renault CLIP command VP008. Confirm ET061 shows learning completed, then engage and verify every gear. Check actuators or internal gearbox mechanics if learning fails.
DF190	Clutch-position learning fault	Run Renault CLIP command VP017. Cycle the ignition and confirm ET064 shows learning completed.

Source: Renault workshop manual MR-410-X83-21B000, PA0 robotised gearbox, Vdiag 05 and 09.

The post Elf Speedmatic robot oil appeared first on tecshift.eu.

REPAIR SERVICE (Stage 2) for Trafic Vivaro Gearbox control unit Tiptronic Robot

admin — Wed, 11 Dec 2024 15:07:58 +0000

REPAIR SERVICE (Stage 2) for Trafic Vivaro Gearbox control unit Tiptronic Robot

RENAULT MASTER II 2.5 DCI
RENAULT TRAFIC II 2.5 DCI / 2.0 DCI
NISSAN INTERSTAR 2.5 DCI
NISSAN PRIMASTAR 2.5 DCI / 2.0 DCI
VAUXHALL MOVANO 2.5 DCI
VAUXHALL VIVARO 2.5 DCI / 2.0 DCI

OEM PART NUMBERS:
309105236R / 309100043R / 8200617985 / 8200983194 / 8200831969 /8200912223 / 8200104609 / 309101331R

Typical foults

DF068 0805 Clutch position sensor circuit
DF069 0914 Selection position sensor circuit
DF070 0904 Engagement position sensor circuit
DF071 0750 Clutch Solenoid valve circuit
DF072 0755 Engagement Solenoid valve 1 circuit
DF073 0760 Engagement solenoid valve 2 circuit
DF074 0765 Selection Solenoid valve 1 circuit
DF075 0770 Selection Solenoid valve 2 Circuit
DF076 0901 Clutch Control
DF077 2711 Gearbox servo Control
DF078 0944 Hydraulic servo Control

DF166 O932 Pressure Sensor Circuit
DF173 C4O1 Injection multiplex signal consistency
DF180 1710 Hydraulic pump
DF181 0919 Gear selection impossible
DF183 C140 No UCH multiplex signal
DF185 C121 No ABS/ESP multiplex signal
DF187 0949 Programming
DF225 0613 Control unit (EEPROM”)
DF229 500B Invalid ABS brake multiplex signal
DF233 1730 Computer

Gearbox actuator installation after repair service:

Its not plug and play device. Unit needs adaptation.
If no adaptation or incorrect fitment – hydraulic unit can not select gears, the clutch will fail, the unit can start leak the car can get stuck in gear.
Fits only PA0 and PK0 semi automatic gearboxes

PART REPLACEMENT REQUIRES THE COMPULSORY REMOVAL OF THE WHOLE SEQUENTIAL SYSTEM AND THE IMPLEMENTATION OF THE FOLLOWING PROGRAMMING AND CONFIGURATION PROCEDURES

To program clutch check that the engine coolant temperature is above 80°C and that parameter PRO95 Clutch temperature is below 180″C. Repeat drive50-100 meters at half-load 6 times to program the clutch progressivity.

Before replacement recommended to check the faults and clear the computer fault memory (some faults are stored when the command modes are used) or deal with the present faults.
Carry out a road test followed by another check using the diagnostic tool.

The post REPAIR SERVICE (Stage 2) for Trafic Vivaro Gearbox control unit Tiptronic Robot appeared first on tecshift.eu.

REPAIR SERVICE for Trafic Vivaro Gearbox control unit Tiptronic Robot

admin — Fri, 24 May 2024 11:34:44 +0000

REPAIR SERVICE for Trafic Vivaro Gearbox control unit Tiptronic Robot

RENAULT MASTER II 2.5 DCI
RENAULT TRAFIC II 2.5 DCI / 2.0 DCI
NISSAN INTERSTAR 2.5 DCI
NISSAN PRIMASTAR 2.5 DCI / 2.0 DCI
VAUXHALL MOVANO 2.5 DCI
VAUXHALL VIVARO 2.5 DCI / 2.0 DCI

OEM PART NUMBERS:
309105236R / 309100043R / 8200617985 / 8200983194 / 8200831969 /8200912223 / 8200104609 / 309101331R

Typical foults

Gearbox actuator installation after repair service:

PART REPLACEMENT REQUIRES THE COMPULSORY REMOVAL OF THE WHOLE SEQUENTIAL SYSTEM AND THE IMPLEMENTATION OF THE FOLLOWING PROGRAMMING AND CONFIGURATION PROCEDURES

The post REPAIR SERVICE for Trafic Vivaro Gearbox control unit Tiptronic Robot appeared first on tecshift.eu.

We can buy Vivaro Trafic car with robot defect !!!

admin — Mon, 23 Oct 2023 14:18:45 +0000

We can buy Vivaro Trafic car with robot defect !!!
Contact us , send pictures , do agreement, receive money !!!

Nous pouvons acheter votre voiture Vivaro Trafic avec un défaut de robot !!!
Contactez-nous, envoyez des photos, faites un accord, recevez de l’argent !!!

Vi kan köpa din Vivaro Trafic bil med robotdefekt !!!
Kontakta oss , skicka bilder , gör avtal, ta emot pengar !!!

Wir können Ihr Vivaro Trafic Auto mit Roboterdefekt kaufen!!!
Kontaktieren Sie uns, senden Sie Bilder, machen Sie eine Vereinbarung, erhalten Sie Geld !!!

The post We can buy Vivaro Trafic car with robot defect !!! appeared first on tecshift.eu.

Exchange deposit for Renault SHIFT SELECTOR

admin — Thu, 09 Jun 2022 17:39:57 +0000

This is exchange sale - you need to return old part.

100 eur deposit required.

New item will be sent after receiving deposit.
Deposit will be returned after receiving old shift selector.

If no deposit - the exchange unit (old shift selector) you need to ship first.

All shift selectors we are selling - 100% tested and 100% working without faults . We do test for each buyer for 10 hours and 5.000 gear engagements eaqual 3 months city driving. and 15 minutes driving test recorded on video with live data from robot. Printed test results will be enclosed.

Why we are do sutch tests? Its possible you have wrong diagnosis and your problem is not gear shifter at all.

Yes you can return shifter, but we will charge you 50 eur for shifter testing.

The post Exchange deposit for Renault SHIFT SELECTOR appeared first on tecshift.eu.

Exchange deposit Trafic Vivaro GEARBOX CONTROL UNIT

admin — Mon, 07 Sep 2020 11:48:07 +0000

Deposit for exchange order. We will refund after return exchange unit (old robot) No exchange unit (old robot) return - no deposit return.

Dépôt pour ordre d'échange. Nous vous rembourserons après retour de l'unité d'échange (ancien robot) Pas de retour d'unité d'échange (ancien robot) - pas de retour de caution.

Kaution für Umtauschbestellung. Wir erstatten nach Rückgabe Umtauscheinheit (alter Roboter) Keine Umtauscheinheit (alter Roboter) Rückgabe - keine Anzahlung Rückgabe.

Depósito por orden de cambio. Reembolsaremos después de la devolución de la unidad de cambio (robot antiguo) Sin devolución de la unidad de cambio (robot antiguo), sin devolución de depósito.

Insättning för utbytesorder. Vi återbetalar efter returbytesenhet (gammal robot) Ingen bytesenhet (gammal robot) retur - ingen insättningsretur.

The post Exchange deposit Trafic Vivaro GEARBOX CONTROL UNIT appeared first on tecshift.eu.

ECU Kit 2,5 2006 – 2014 trafic vivaro primastar 0281 017066, 8200635663, 8201105653

admin — Wed, 04 Oct 2017 09:14:06 +0000

ECU Kit 2,5 engine computer, body computer, 1 key

2006 - 2014 trafic vivaro primastar

code engine computer 0281 017066, 8200635663, 8201105653

UCH N3 G2005 X83

P8200790995 - - F, 00285248, 28121287 - 1A

Software version A2 V3.04

Selling on exchange bases. You will need return old set

The post ECU Kit 2,5 2006 – 2014 trafic vivaro primastar 0281 017066, 8200635663, 8201105653 appeared first on tecshift.eu.

Trafic Vivaro GEARBOX CONTROL UNIT Tiptronic Robot Automatic Actuator 1/2 year warranty 309100043R 309105236R 309101331R

admin — Thu, 23 Mar 2017 16:28:30 +0000

This is exchange (will need to return old part) sale

Exchange deposit Trafic Vivaro GEARBOX CONTROL UNIT

Tecshift Easytronic Quickshift Tiptronic 309105236R 309100043R 309101331R

We selling only tested units. Tests clutch position, engagement position, selection position hydraulic pressure drops, clutch progression, clutch open position, slip point . Results will be provided.

Fits :

RENAULT MASTER II 2.5 DCI
RENAULT TRAFIC II 2.5 DCI / 2.0 DCI
NISSAN INTERSTAR 2.5 DCI
NISSAN PRIMASTAR 2.5 DCI / 2.0 DCI
VAUXHALL MOVANO 2.5 DCI
VAUXHALL VIVARO 2.5 DCI / 2.0 DCI

OEM PART NUMBERS:
309105236R / 309100043R / 8200617985 / 8200983194 / 8200831969 /8200912223 / 8200104609 / 309101331R

PART REPLACEMENT REQUIRES THE COMPULSORY REMOVAL OF THE WHOLE SEQUENTIAL SYSTEM AND THE IMPLEMENTATION OF THE FOLLOWING PROGRAMMING AND CONFIGURATION PROCEDURES

Typical foults

The post Trafic Vivaro GEARBOX CONTROL UNIT Tiptronic Robot Automatic Actuator 1/2 year warranty 309100043R 309105236R 309101331R appeared first on tecshift.eu.